08-2012, rev. 0812 www.te.com ? 2012 tyco electronics corporation, a te connectivity ltd. company. datasheets and product specifcation ac - cording to iec 61810-1 and to be used only together with the defnitions section. datasheets and product data is subject to the terms of the disclaimer and all chapters of the defnitions section, available at http://relays.te.com/definitions datasheets, product data, defnitions sec - tion, application notes and all specifcations are subject to change. 1 n limiting continuous current 130a at 85c n current switching ability up to 300a n suitable for voltage levels up to 24vdc n heat, moisture and vibration resistant n minimal contact resistance n dustproof and sealed versions typical applications engine control, glow plug, heated front screen, preheating systems (e.g. for diesel engines, catalytic converters), switches for loading ramps, start/stop. contact data contact arrangement 1 form a, 1 no 1 form b, 1 nc 1 form c, 1 co 1 form x, 1 no dm rated voltage 12vdc/24vdc max. switching voltage depends on load parameters a) rated current, cable 25mm 2 130a at 85c limiting continuous current 23c, load cable 16mm 2 130a 85c, load cable 16mm 2 120a 125c, load cable 16mm 2 60a 23c, load cable 25mm 2 180a 85c, load cable 25mm 2 130a 125c, load cable 25mm 2 70a limiting making current, load current max. 3s on, make/break ratio 1:10 300a limiting breaking current 300a contact material agsno 2 min. recommended contact load 4) 1a at 5vdc initial voltage drop, typ. at 100a 70mv frequency of operation, with/without load 6 ops./min operate/release time typ. at nominal voltage 25/8ms electrical endurance form a contact (no), resistive load, cyclic temperature:+23c >5x10 4 cycles at 300a, 13.5vdc mechanical endurance >10 7 ops. a) please contact te relay application engineer. coil data rated coil voltage 12/24vdc rated coil power 3.3w 1) max. coil temperature 155c coil versions, dc coil 1) coil rated operate release coil rated coil code voltage voltage voltage resistance power vdc vdc vdc ?10% w 001 12 7.2 1.2 37 3.9 002 24 14.4 2.4 141 4.1 1) with resistor. all fgures are given for coil without preenergization, at ambient temperature +23c. coil operating range insulation data initial dielectric strength between contact and coil 1000vac rms load dump test iso 7637-1 (12vdc), test pulse 5 vs=+86.5vdc iso 7637-2 (24vdc), test pulse 5 vs=+200vdc high current relay 150 automotive relays high current devices 300 does not take into account the temperature rise due to the contact current e = pre-energization ecr1449-v does not take into account the temperature rise due to the contact current e = pre-energization f132_fcw2b
08-2012, rev. 0812 www.te.com ? 2012 tyco electronics corporation, a te connectivity ltd. company. datasheets and product specifcation ac - cording to iec 61810-1 and to be used only together with the defnitions section. datasheets and product data is subject to the terms of the disclaimer and all chapters of the defnitions section, available at http://relays.te.com/definitions datasheets, product data, defnitions sec - tion, application notes and all specifcations are subject to change. 2 high current relay 150 (continued) automotive relays high current devices other data (continued) terminal type screw cover retention pull force 500n push force 500n terminal retention pull force 150n push force 150n resistance to bending 20n force applied to side 20n torque 5nm weight approx. 220g (7.8oz) packaging unit 50 pcs. 2) no change in the switching state >10s. other data eu rohs/elv compliance compliant ambient temperature -40c to +125c dry heat, iec 60068-2-2 500h at 100c damp heat constant, iec 60068-2-3 (78), ca 500h, 40c, 93% rh degree of protection dustproof: ip54 (iec 60529), rt i (iec 61810) sealed: sealing in accordance with iec 68 immersion cleanable: ip67 (iec 60529), rt iii (iec 61810) corrosive gas iec 60068-2-42 10 days iec 60068-2-43 10 days vibration resistance (functional) iec 60068-2-6 (sine sweep) 10 to 200hz >5g 2) shock resistance (functional) iec 60068-2-27 (half sine) 6ms >20g 2) drop test, free fall iec 60068-2-32 1m onto concrete nor 1 form a, 1 no with resistor terminal assignment 54 3 1 2 5 3 1 2 55 b 1 2 cor 1 form c, 1 co with resistor nobrr 1 form x, 1 no dm with resistor dimensions no and no dm version view of the terminals bottom view *) alternatively 5b for form x, 1 no dm with resistor. connector information amp superseal 1.5 series coil side - receptacle connector 282080-1 - single wire seal 281934-2 - contact 282110-1 load side cable lug m6, maximum cable section 25 mm2 te1666-x1 screw terminals m6 connector 2-pole 7.5 x 6.5 13.5 63 84 40 45 17 65.2 71 ? 6.5 te1666-x1 screw terminals m6 connector 2-pole 7.5 x 6.5 13.5 63 84 40 45 17 65.2 71 ? 6.5 te1667-61 15.5 *)
08-2012, rev. 0812 www.te.com ? 2012 tyco electronics corporation, a te connectivity ltd. company. datasheets and product specifcation ac - cording to iec 61810-1 and to be used only together with the defnitions section. datasheets and product data is subject to the terms of the disclaimer and all chapters of the defnitions section, available at http://relays.te.com/definitions datasheets, product data, defnitions sec - tion, application notes and all specifcations are subject to change. 3 high current relay 150 (continued) automotive relays high current devices product code structure typical product code v23132 -a2 001 -a 2 00 type v23132 high current relay 150 contact arrangement a2 1 form a, 1 no d2 1 form b, 1 nc b2 1 form x, 1 no dm e2 1 form c, 1 co coil 001 12vdc 002 24vdc protection class a ip54 b ip67 contact material 2 agsno 2 standard version 00 standard dimensions co version view of the terminals 2 pole tab connector te amp mcp 1.2 load terminals screw m6 max. torsion of screw bolts: 5nm 132co_dd1 product code arrangement coil circuit coil suppr. protect. contact mat. terminals part number v23132-a2001-a200 1 form a, 1 no 12vdc nor resistor ip54 agsno2 screw 1393315-2 v23132-a2001-a200-ev-usbx*) 7-1414968-8*) v23132-a2001-b200 ip67 1416010-1 v23132-a2001-b200-ev-usbx*) 2-1414939-2*) v23132-b2002-a200 1 form x, 1 no dm 24vdc nobrr ip54 1393315-9 v23132-b2002-b200 ip67 1-1393315-1 v23132-b2002-b200-ev-usbx*) 5-1414968-1*) v23132-d2001-b200 1 form b, 1 nc 12vdc ncr on request v23132-e2001-a200 1 form c, 1 co 12vdc cor ip54 9-1415001-5 other types on request. this list represents the most common types and does not show all variants covered by this datasheet. *) americas market only.
|
